Rotax 582 no spark. Rotax 582 ignition problem

Discussion in 'apk' started by Zukree , Thursday, February 24, 2022 11:19:44 AM.

  1. Fenrizil

    Fenrizil

    Messages:
    88
    Likes Received:
    3
    Trophy Points:
    3
    By Ragwing - Tue Dec 17, Wed Apr 24, Simple replacement of the electronic ignition box can then result in a repeat failure from the same cause after a short time. I waited until it ran rough on the ground and switched to the left "mag" only, and the engine quit. I notice there is no spark firing and some fuel coming when I remove the spark plug.
    rotax 582 not geting spark - Rotax 582 no spark.
     
  2. Akimuro

    Akimuro

    Messages:
    714
    Likes Received:
    10
    Trophy Points:
    6
    I have rotax (50h) I got difficult to start engine at all. I notice there is no spark firing and some fuel coming when I remove the spark plug.Either email addresses are anonymous for this group or you need the view member email addresses permission to view the original message.
     
  3. Zolorisar

    Zolorisar

    Messages:
    673
    Likes Received:
    25
    Trophy Points:
    4
    I got no spark on the rear coil sparkpluggs. 2)I doublechecked by exstending the rearcoil harness to the heavenmanga.online the frontcoil sparkplugs were.I had a dead left mag since the firs start.
    Rotax 582 no spark.
     
  4. Zugal

    Zugal

    Messages:
    726
    Likes Received:
    9
    Trophy Points:
    6
    Try unplugging the connector coming from the coils/charging system there could be chaffed wires grounding out the CDI's. Careful though don't.Rotaxliquid cooled aircraft engine troubleshooting.
    Rotax 582 no spark.
     
  5. Kigagar

    Kigagar

    Messages:
    948
    Likes Received:
    18
    Trophy Points:
    3
    At less than rpm the Ducati system produced no spark at all (not a weak spark, no spark). Be sure to pull your cord with a brisk full 6 to 8 foot stroke of.Failure is detected when a loss of rpm is noticed and or an ignition check is done on the system during preflight.
     
  6. Daitaur

    Daitaur

    Messages:
    750
    Likes Received:
    32
    Trophy Points:
    3
    Both capacitive discharge ignition systems on my Rotax appear to have died spark plug caps grounded; just the sort of thing that would happen if you.Cancel Submit.
     
  7. Tojat

    Tojat

    Messages:
    532
    Likes Received:
    5
    Trophy Points:
    5
    The only reported problems to date with the ignition system on the Rotax have been with ignition coil failure. This is the external coil mounted on the carb.When connecting the coil leads on one coil the ground wire will go to the 1 side of the coil, with the points wire going to the 15 side.
    Rotax 582 no spark.
     
  8. Arashisida

    Arashisida

    Messages:
    704
    Likes Received:
    29
    Trophy Points:
    1
    After much testing, the ignition coil had a wiring break within the end terminal insulation block (only found by accident while checking.You do not have permissions to reply to this topic.
     
  9. Kazitilar

    Kazitilar

    Messages:
    972
    Likes Received:
    33
    Trophy Points:
    7
    ) Oil pump for fresh oil engine lubrication (ROTAX DCDI). ) Fitting of the stator plate assembly on Type UL.Careful though don't fire it up without the plugs grounded to the engine somehow you can blow the CDI that way.
     
  10. Shaktizshura

    Shaktizshura

    Messages:
    702
    Likes Received:
    13
    Trophy Points:
    0
    no spark, the spark plug protector and the ignition cable and finally the ignition unit should be checked. IGNITION UNIT. The ROTAX engine is equipped with.Then the frontcoil sparkplugs were working ok.
     
  11. Tojagore

    Tojagore

    Messages:
    241
    Likes Received:
    10
    Trophy Points:
    2
    Page 1 of 3 Start Prev 1 2 3 Next End.
     
  12. Kajihn

    Kajihn

    Messages:
    20
    Likes Received:
    11
    Trophy Points:
    6
    I cant see someone putting a in the avid without electric start, but hey, stranger things have been done
     
  13. Fegami

    Fegami

    Messages:
    138
    Likes Received:
    25
    Trophy Points:
    7
    forum? I think the rpm idea might be the problem ill pull harder.Forum Rotax 582 no spark
     
  14. Kazranris

    Kazranris

    Messages:
    96
    Likes Received:
    17
    Trophy Points:
    1
    Kevin, I found the following extract in the latest copy of 'Tech Topics', a bi-annual publication for members of the BMAA :- ROTAX, Electronic Ignition Faults The failure of the electronic ignition unit fitted to the above engines, need not necessarily be due only to a fault in the electronics box itself, it could be caused by a malfunction of the trigger coil installed in the engine.
     
  15. Dazil

    Dazil

    Messages:
    347
    Likes Received:
    11
    Trophy Points:
    2
    Some pilots are using resistor plugs to suppress engine noise when then are using radios.
     
  16. Zulkishakar

    Zulkishakar

    Messages:
    42
    Likes Received:
    24
    Trophy Points:
    1
    Good luck figuring out the problem.
     
  17. Kajijind

    Kajijind

    Messages:
    234
    Likes Received:
    25
    Trophy Points:
    7
    That's what it's there for!
     
  18. Bak

    Bak

    Messages:
    532
    Likes Received:
    17
    Trophy Points:
    7
    While not part of the ignition system problems have been reported with the tachometer circuit on the
     
  19. Kajirisar

    Kajirisar

    Messages:
    775
    Likes Received:
    5
    Trophy Points:
    2
    Having had a couple of Ducati bikes, I'm not sure if I'm more scared or shocked that there are Ducati electronics in the air somewhere!
     
  20. Togor

    Togor

    Messages:
    91
    Likes Received:
    25
    Trophy Points:
    2
    The engine should have its ignition timing checked every 50 hours or twice a year.
     
  21. Shajind

    Shajind

    Messages:
    925
    Likes Received:
    33
    Trophy Points:
    3
    Existing user?
     
  22. Meziramar

    Meziramar

    Messages:
    574
    Likes Received:
    18
    Trophy Points:
    7
    The top end consists of engine parts above the crankcase.
     
  23. Mezijora

    Mezijora

    Messages:
    584
    Likes Received:
    31
    Trophy Points:
    1
    You do not have permissions to reply to this topic.
     
  24. Mor

    Mor

    Messages:
    585
    Likes Received:
    22
    Trophy Points:
    1
    This website uses cookies to manage authentication, navigation, and other functions.
     
  25. Kagajas

    Kagajas

    Messages:
    409
    Likes Received:
    16
    Trophy Points:
    5
    Posted 18 Sep
    Rotax 582 no spark.
     
  26. Faulkree

    Faulkree

    Messages:
    466
    Likes Received:
    14
    Trophy Points:
    4
    Thats what we are here for!
     
  27. Vudal

    Vudal

    Messages:
    765
    Likes Received:
    31
    Trophy Points:
    2
    forum? Sign in here.
     
  28. Vokus

    Vokus

    Messages:
    756
    Likes Received:
    17
    Trophy Points:
    4
    If it is only two plugs that aren't firing, it could be one black box that is bad, or wiring to that box.
     
  29. Kazijora

    Kazijora

    Messages:
    19
    Likes Received:
    24
    Trophy Points:
    6
    forum? My favoured solution in such situations is to remove the plug-and-socket, and use a piece of choc-block with both wires gripped by both screws.
     
  30. Tomuro

    Tomuro

    Messages:
    290
    Likes Received:
    10
    Trophy Points:
    1
    I suffer from Dyslexia
     
  31. Shaktit

    Shaktit

    Messages:
    590
    Likes Received:
    4
    Trophy Points:
    7
    Look up ultralightnews.
     
  32. Nijora

    Nijora

    Messages:
    700
    Likes Received:
    8
    Trophy Points:
    3
    The ignition coils have been reported to fail, and my recommendation is replacement at hours, or at the first sign of problems.
     
  33. Bakazahn

    Bakazahn

    Messages:
    817
    Likes Received:
    26
    Trophy Points:
    6
    For general guidance on electrical troubleshooting
     
  34. Kasida

    Kasida

    Messages:
    394
    Likes Received:
    17
    Trophy Points:
    6
    Kevin Dean.Forum Rotax 582 no spark
     
  35. Taugor

    Taugor

    Messages:
    945
    Likes Received:
    23
    Trophy Points:
    0
    You need to be a member in order to leave a comment.
    Rotax 582 no spark.
     

Link Thread

  • 2014 nissan versa cvt range sensor

    Digor , Saturday, March 5, 2022 10:12:31 AM
    Replies:
    28
    Views:
    2104
    Sagrel
    Friday, March 11, 2022 1:56:16 PM
  • Elm327 not pairing

    Nejin , Friday, February 25, 2022 10:35:38 AM
    Replies:
    5
    Views:
    1758
    Grogrel
    Friday, March 11, 2022 6:40:50 AM
  • Yahoo com gmail com hotmail com

    Shalkree , Monday, March 14, 2022 5:00:17 PM
    Replies:
    18
    Views:
    5121
    Kelkree
    Saturday, March 5, 2022 6:42:54 AM
  • Spotify play bot

    Vudor , Wednesday, March 2, 2022 2:13:05 AM
    Replies:
    16
    Views:
    1155
    Akinozragore
    Friday, February 25, 2022 6:46:47 PM